There ought to be a little panel near the sunroof which you can pry off and utilize the unexpected emergency crank (should be while in the toolkit of the vehicle) to manually crank the sunroof closed. I feel this information is also documented while in the proprietor's handbook. - Wayne at Pelican Parts Matt

I not too long ago obtained a 2003 bmw 325i my initially BMW and i Once i place the sunroof up it doesnt want to close each of the way down it just makes type of a clicking noise any notion what that can be

C: Toss some towels or relocating blankets around the tops of the seats to shield them from hurt as you Enable the assembly down. There is a large tab inside the front in the assembly that matches right into a slot while in the metal body of the car--this will delay the front Section of the roof as you decrease it. Should you recline your seats every one of the way again, you should be in a position to maneuver the assembly away from the car. I managed to decrease the assembly and take away it myself, but I had been working with a task car and didn't care also much regarding the upholstery. I like to recommend you may have the assistance of the assistant If you don't want the sunroof assembly to scratch your interior. D: This can be what the entire assembly seems like right after it has been removed from the car. To make The task easier, you are able to clear away the metallic panel through the assembly just before eradicating it.

You will need to take away the cassette, then take away the glass and location the cables and tracks in precisely the same placement, then attache the glass and motor. I would presume a thing is damaged, it should not head out of your time for no purpose.- Nick at Pelican Parts Kie

I just experienced the roof repainted on my ‘ninety five M3 to treatment a blistering problem. Following the store reassembled the sunroof, the lean function does not do the job effectively. The metal sunroof itself tilts for the rear as it must, though the headliner continues to be shut flush with the body so there isn't any air entering the vehicle from outside the house. If I recall accurately, when it’s working correctly, I am able to slip my fingers underneath the again side of your uptilted rear from the sunroof panel.

When the sunroof doesn't consider to maneuver when urgent the switch, it may be some thing similar to a fuse. If it attempts to move it may be a problem with the guides or keep track of inside the sunroof. - Nick at Pelican Parts Jai

If you need much more accessibility and wish to get rid of the entire assembly, then confer with click here Image two for instructions. I like to recommend you seize you a helper, mainly because it is not hard to wreck your interior trim if you are trying to eliminate the entire sunroof assembly you.

Sounds to me like some thing is jamming it from the rail spot. You'll want to remove the Sunshine shade and glass to examine the tracks and generate. Try to look for broken plastic items or signals of damage. - Nick at Pelican Parts Mikki

Hello, the sunroof in my motor vehicle functions wonderful, but I figure it ought to need to have some form of lubing specifically in my dry climate in advance of it fails. Can this be done without disassembling? What will be the appropriate product or service? Many thanks!

I think that the course of action is similar to the a single revealed in this article - the headliner is 1 piece and needs to get replaced in a bit. - Wayne at Pelican Parts

the cable ends attach for the slide / guides on both sides. The motor is installed when the sunroof panel is during the placement it is possible to eliminate the fasteners with the panel. - Nick at Pelican Parts slk57

I should tun it shut manually with an allen wrench and then it'll do the job good. A person advised that I have to re-sync the motor Though I did not get rid of the motor as Component of the repair service. Does this sound correct and if so, how can I sync the motor?

A slide rail may very well be broken. Could you share a photo of the damaged aspect so we could see what has failed? I'll be able that can assist you a lot more then. You'll have to eliminate the sunroof panel to obtain the rails and guides. The tech short article right here reveals how to remove the panel. - Nick at Pelican Parts

Hi there, I have a 2006 525d estate with the panoramic roof. Roof will go every one of the way back to open up but won't near all over again Except if you go through the whole initialisation procedure.